红外测温过程中灰度值漂移的修正

孙志远; 朱玮; 乔彦峰

红外测温过程中灰度值漂移的修正

中国科学院长春光学精密机械与物理研究所,吉林长春 130033

详细信息

作者简介:

孙志远(1982—),男,辽宁沈阳人,博士研究生,主要从事红外辐射测量方面的研究。 E-mail:zhiyuansun1982@yahoo.com.cn

中图分类号: TN219
计量
- 文章访问数: 4560
- HTML全文浏览量: 500
- PDF下载量: 1922
- 被引次数: 0
出版历程
- 收稿日期: 2010-04-16
- 修回日期: 2010-06-26
- 刊出日期: 2010-08-25

Amendment of gray drift in infrared temperature measurement

Changchun Institute of Optics,Fine Mechanics and Physics,Chinese Academy of Sciences,Changchun 130033,China

摘要

摘要: 对基于中波红外焦平面探测器实现目标的表面温度测量进行了理论及实验研究。介绍了红外测温系统的组成和测量原理,建立了红外探测器测温模型。分析了标定过程中出现的红外探测器灰度值漂移现象,通过4种不同的实验方法总结了红外探测器灰度值漂移的规律,根据这些漂移规律提出了漂移补偿的方法。最后,以黑体为目标进行了测温实验。结果显示,漂移补偿前后的测温误差分别为1.965 ℃和0.335 ℃,表明测温精度得到了很大的改善。
- 红外探测器 /
- 红外测温 /
- 灰度值漂移 /
- 漂移补偿
Abstract: The surface temperature measurement of temperature target based on a medium wave infrared detector was researched theoretically and experimentally in this paper. The constitution and measurement principle of the system were introduced and a temperature measurement model for the infrared detector was established. The gray drift characteristics of the infrared detector in a calibration were analyzed, and the drift disciplinarians were summarized by four kinds of different experiments. Meanwhile, the drift compensation method was proposed based on the drift disciplinarians. Finally, a temperature measurement experiment was carried out, and the results show that the measurement error before and after drift compensations are 1.965 ℃ and 0.335 ℃, respectively, which indicates that the measurement precision has been improved in a great degree after the compensation.
- infrared detector /
- infrared temperature measurement /
- gray drift /
- drift compensation

HTML全文

参考文献(1)

[1] 屈惠明. 红外成像电子学理论及其关键技术研究 . 南京:南京理工大学 ,2007. QU H M. Research on infrared imaging electronics theory and its key techniques . Najing:Nanjing University of Science and Technology,2007(in Chinese)

[2] MAZIKOWSKI A,HYPSZER R,JEDRZEJIEWSKA-SZCZERSKA M. Modeling of non-contact temperature measurement system using multiwavelength pyrometry
[J]. SPIE,2001,4516:120-124.

[3] 林志强,郑小兵,张磊. 红外探测器光谱响应率定标方法
[J]. 光电工程 ,2008,35(2):118-122. LIN ZH Q,ZHENG X B,ZHANG L. Calibration of spectral responsivity of infrared detector
[J]. Opto-electronic Eng.,2008,35(2):118-122.(in Chinese)

[4] 邢强林. 红外焦平面成像探测辐射特性测量标定方法研究
[J]. 飞行器测控学报 ,2007, 26(4):68-71. XING Q L. Calibration for FPA infrared radiation measuring system
[J]. J. Spacecraft TT&C Technol.,2007,26(4):68-71.(in Chinese)

[5] 刘涛,姜卫东,黎湘,等. 弹道中段目标动态红外辐射特性仿真计算
[J]. 红外与激光工程 ,2008,37(6):955-958. LIU T,JIANG W D,LI X,et al.. Simulation calculation of synamic infrared radiation characteristics of the target in ballistic midcourse
[J]. Infrared Laser Eng.,2008,37(6):955-958.(in Chinese)

[6] 张建奇,方小平.红外物理
[M]. 西安:西安电子科技大学出版社,2004. ZHANG J Q,FANG X P. Infrared Physics
[M]. Xi'an:Xidian University press,2004.(in Chinese)

[7] 郁道银,谈恒英.工程光学
[M]. 北京:机械工业出版社,1999. YU D Y,TAN H Y. Engineering Optics
[M]. Beijing:China Machine Press,1999.(in Chinese)

[8] 吴晗平. 红外辐射大气透过率的工程理论计算方法研究
[J]. 光学精密工程 ,1998,6(4):35-43. WU H P. Research into theoretical calculation method on engineering of transmittance of infrared radiation through stmosphere
[J]. Opt. Precision Eng.,1998,6(4):35-43.(in Chinese)